46 Cars Inc

• High-voltage battery state-of-health measured at 97.8% via dealer diagnostic tool, consistent with 57,026 km
• Cell balance variance within normal spec, max deviation 0.12V across modules
• Pack voltage stable at nominal Ultium platform voltage, no fault codes present
• Charge acceptance normal on Level 2 and DC fast-charge, no degradation concerns noted

• Level 1, Level 2, and DC fast-charge ports inspected and functioning normally
• Charge flap operates smoothly, no damage or binding
• Onboard charger communicates correctly with external EVSE units
• Charge indicator lights behave as expected during connection and charging

• Front and rear drive motors operate smoothly with no abnormal noises under load
• Inverter units scanned, no DTCs or isolation faults detected
• Power delivery linear and smooth across throttle range in all drive modes
• High-voltage isolation resistance within manufacturer specification

• Regenerative braking blends seamlessly with friction brakes, no grab or surge
• One-pedal mode engages and disengages as intended
• Brake-by-wire response consistent and predictable
• No DTCs related to regen system stored in any module

• Battery thermal management system operating normally, cooling and heating cycles confirmed
• Coolant level full, clean, correct colour per GM spec
• No overheating events or thermal warnings during inspection
• Coolant circulation pump operational, no leaks at fittings or lines

• 12V auxiliary battery voltage at 12.6V static, acceptable but approaching typical service life threshold
• DC-DC converter operating correctly, maintains 13.8-14.2V under low-voltage load
• All low-voltage loads supported without voltage drop
• Battery load test indicates marginal capacity remaining

Notes: 12V auxiliary battery may need replacement within the next 6-12 months; monitor during cold weather.

• Estimated full-charge range at 100% SOC displays 498 km, original EPA-equivalent rating was approximately 510 km
• GOM behaviour stable and consistent with driving conditions
• Approximately 2.4% range reduction observed, within normal degradation curve for mileage
• No rapid range drop or erratic GOM behaviour noted

• Front brake pads at 6mm, rear pads at 7mm, both within serviceable range
• Rotors smooth, no scoring or excessive wear
• Brake fluid level full, colour clear to slightly amber, within service interval
• Parking brake engages and releases normally, brake pedal firm

Notes: Front pads will likely need replacement within 20,000-25,000 km depending on driving habits.

• Front tread depth at 6/32nds, rear tread depth at 5/32nds, even wear pattern
• All four tires are matching OEM-spec all-seasons, no sidewall damage
• Wheels free of bends or cracks, minor curb rash noted on one wheel
• TPMS sensors reading correctly on all four corners

Notes: Rear tires approaching replacement threshold; recommend budgeting for a new rear set within 10,000-15,000 km.

• Bushings, ball joints, and tie rods inspected with no play or deterioration
• Shocks and struts show no signs of leakage, ride height normal
• Steering responsive with no excessive play
• No pulling or wandering noted on straight-road test, alignment appears within spec

• 12V battery voltage stable, charging voltage from DC-DC converter normal
• Full module scan completed, no active DTCs stored in any control unit
• All exterior and interior lights functional, including headlights and turn signals
• Infotainment system, wipers, and power accessories all operating as designed

• Airbag system modules scan clean, no DTCs, SRS indicator cycles normally
• ABS and ESC/traction control systems operational, no faults
• Backup camera displays clearly with proper guidelines
• ADAS features including lane keep, automatic emergency braking, and adaptive cruise tested and functioning

• Body panel alignment uniform, gaps consistent across doors, hood, and tailgate
• Black paint finish consistent across all panels, no orange peel or mismatch noted
• No visible damage, dents, or scratches of significance
• Interior shows minimal wear consistent with mileage, seats, controls, and electronics all functional, no odour

Notes: No reported accidents per Carfax auto-scan.

• Urban and highway test completed, acceleration smooth and linear in all modes
• Braking confident and progressive, no vibration or pulsation
• Steering precise, no unusual noises from drivetrain or suspension
• No DTCs appeared during or after the drive cycle, all systems remained nominal