46 Cars Inc

• High-voltage battery state-of-health measured at 97.8% via PIWIS diagnostic scan
• Cell balance/variance within spec at 0.021V maximum deviation across modules
• Pack voltage nominal at 612V with no anomalous cell groups identified
• Charge acceptance normal on DC fast-charge — no degradation flags set

• Level 2 (J1772) and DC fast-charge (CCS) ports tested operational — both accepted charge without fault
• Onboard 11kW charger functioning normally on Level 2 input
• Charge flap mechanism opens and latches correctly; charge indicator LEDs cycle through expected sequence
• No communication faults between vehicle and external EVSE during test

Notes: Minor scuffing on CCS port dust cover cosmetically noted but does not affect function.

• Front and rear PSM motors operate smoothly — no abnormal noises under load or coast-down
• Inverter/charger unit reporting no DTCs; isolation resistance within specification at 550 Mohm
• Power delivery smooth and linear across throttle range in all drive modes
• Launch control tested — engages and delivers expected GTS performance without hesitation

• Regenerative braking blends seamlessly with friction brakes — no transition grab or pulsation noted
• One-pedal mode (Auto Regeneration Plus) functions correctly and holds vehicle at stop
• Brake-by-wire pedal feel consistent and firm — no sponginess or delayed response
• Regen mapping in Normal, Sport, and Sport Plus modes all operating as designed

• Battery thermal management system cycling normally — pack temperature maintained at 24°C during test
• High-voltage coolant loop level full with Porsche-spec G40 coolant — clean, no contamination
• No overheating events or thermal warnings logged in any cooling module
• Front radiator cores inspected — no blockage or debris accumulation

• 12V auxiliary battery voltage at rest measured 12.6V — within acceptable range
• DC-DC converter outputting 14.2V under load — supporting all low-voltage accessories normally
• No parasitic draw detected after shutdown cycle; module communication clean
• Lead-acid auxiliary battery manufactured in 2021 — approaching end of expected service life for AGM type

Notes: 12V auxiliary battery showing its age for model year — recommend replacement within 12 months.

• Estimated full-charge range at 100% SOC displayed 326 km on GOM — consistent with 30,944 km of use
• Original EPA-equivalent rating was approximately 388 km — representing ~16% observed reduction
• GOM behaviour stable — adjusts predictably with driving style and climate settings
• No battery degradation warnings or capacity-loss DTCs stored

Notes: Range reduction is typical for this mileage and usage; winter range may be further reduced in Canadian conditions.

• Front pad thickness at 5.2mm (originally ~12mm) — approaching half service life
• Rear pad thickness at 6.8mm — remaining service life adequate
• Rotors smooth and within spec — no scoring, heat cracking, or excessive lip
• Brake fluid clear with correct level; moisture content at 1.2% — not yet due for replacement

Notes: Front brake pads will need attention within ~15,000 km.

• Front tire tread depth at 5.5mm — Bridgestone Potenza Sport 225/45R21 summer tires
• Rear tire tread depth at 5.0mm — matching set on 21-inch Taycan GTS wheels
• Wear pattern even across all four tires — no cupping or feathering observed
• TPMS sensors reading correctly on all four wheels; no sidewall damage; wheels clean of curb rash

Notes: Summer performance tires only — winter tire set recommended for Canadian climate.

• Front and rear air suspension self-levelling correctly — no ride-height faults or compressor noise
• Bushings, ball joints, and tie rods inspected — no play, tearing, or deterioration
• Steering rack tight with no play; no wandering or pulling on straight road
• Adaptive dampers responding to drive-mode changes — Sport Plus lowered ride height confirmed

• Full PIWIS scan completed — all control modules clear with no stored or pending DTCs
• All exterior lighting functional including matrix LED headlights and dynamic turn signals
• Infotainment, PCM navigation, Apple CarPlay, and all power accessories operate without fault
• Wipers, defrost, heated seats, and steering wheel all functioning correctly

• Airbag system modules clear — no crash data or deployment DTCs stored
• ABS and ESC/traction control tested and operational — no warning activation during road test
• Backup camera displays clearly — no image distortion or lag
• ADAS features (adaptive cruise, lane-keeping, autonomous emergency braking) tested and functional

• No reported accidents per Carfax auto-scan
• Body panel alignment consistent across doors, hood, and hatch — gaps uniform
• Paint finish consistent in blue across all panels — no overspray, blistering, or mismatch observed
• Interior shows light wear consistent with 30,944 km; seats, trim, and headliner in excellent condition; no odour

• Urban driving — smooth acceleration from stop, regen blending seamless, no unusual noises
• Highway driving — stable at 110 km/h, no vibration or pull, lane-keeping assist engaged correctly
• Braking from 100 km/h — firm pedal, straight stop, no ABS intervention or pull
• No DTCs appeared during 25 km combined urban and highway road test